-
Alto-Shaam 1220 - page 1
MN-28897 • 02/12 printed i n u . s . a . Combitherm ® Combination Oven / Steamer ES ELECTRIC 6•10 10•10 7•14 10•18 12•20 20•20 VHes-5 VHes -10 • InstallatIon W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 u s a / c a N a d a FaX: 262.251.7067 ? ...
-
Alto-Shaam 1220 - page 2
i Delivery 1 Unpacking 1 Safety Procedures and Precautions 2 Installation Site Requirements 3 Ventilation Requirements 3 Positioning on Site 4 Lifting Instructions 5 Leveling 6 Stand Installation 6 Accessories 7 Specifications, 6•10es 8 Specifications, 6•10esi 9 Specifications, 6•10esiN 10 Specifications, 10•10es 11 Specifications, 10•10e ...
-
Alto-Shaam 1220 - page 3
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 1. DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims section l ...
-
Alto-Shaam 1220 - page 4
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 2. CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard that can or will cause minor o ...
-
Alto-Shaam 1220 - page 5
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 3. SITE INSTALLATION INSTALLATION DANGER IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING ...
-
Alto-Shaam 1220 - page 6
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 4. NOTE: Note dimensions required for doorways and aisles for access of the oven and pallet to the installation site. Transport the oven in an upright and level position only. Do not tilt the oven. ® SITE INSTALLATION INSTALLATION POSITIONING ON SITE Stand the oven in a level po ...
-
Alto-Shaam 1220 - page 7
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 5. SITE INSTALLATION INSTALLATION Lifting Ins tructions Do not lift in this area! Damage t o the components will r esult. Cent er of Gra vity Front View T op View (Fron t) Leg 24” Spacer Board Remov e banding befor e lifting. Place a spacer board(s ) 24” in length, with a min ...
-
Alto-Shaam 1220 - page 8
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 6. SITE INSTALLATION INSTALLATION POSITIONING REQUIREMENTS q In order to ensure proper ventilation, a minimum distance of at least 6-inches (152mm) must be kept from the control panels side (left) of the oven and any adjoining surfaces. NOTE: Additional clearance is needed for se ...
-
Alto-Shaam 1220 - page 9
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 7. ACCESSORIES CombiClean® Tablets — CE-28892 s P E c i a l l y F O r M u l a t E d FOr cOMbitHErM OvENs ➥ t w O (2) c O N t a i N E r s / bOX , 90 PackEts E a c H c O N t a i N E r Combitherm Cleaning Liquid — CE-24750 s P E c i a l l y F O r M u l a t E d FOr cOMbitHErM ...
-
Alto-Shaam 1220 - page 10
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 8. 6•10 es 31-3/8" (796mm) 34-1/16" (864mm) 17-15/16" (456mm) 7-9/16" (191mm) WA TER DRAIN 33-1/8" (840mm) 4-15/16" (125mm) Steam Ve nt (Top) 60-9/16" (1538mm) Water Drain (Back) Tr eated Wa ter Intake (Bottom) Untreated Water Intake (Bottom) ...
-
Alto-Shaam 1220 - page 11
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 9. 6•10 es i 31-3/8" (796mm) 34-1/16" (864mm) 17-15/16" (456mm) 7-9/16" (191mm) WA TER DRAIN 33-1/8" (840mm) 4-15/16" (125mm) Steam Ve nt (Top) 60-9/16" (1538mm) Water Drain (Back) Tr eated Wa ter Intake (Bottom) Untreated Water Intake (Bottom ...
-
Alto-Shaam 1220 - page 12
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 10. 6•10 es iN 32-15/16" (835mm) 35-9/16" (903mm) 21-11/16" (550mm) 5-3/8" (137mm) 6-3/8" (161mm) WA TER DRAIN 33-7/8" (859mm) 35-13/16" (909mm) 2" (50mm) 41-1/16" (1042mm) Water Drain (Side Back) Steam Vent (T op) Electrical Connect ...
-
Alto-Shaam 1220 - page 13
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 11. 10•10 es 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31-3/8" (796mm) 34-1/16" (8 ...
-
Alto-Shaam 1220 - page 14
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 12. 10•10 es i 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31-3/8" (796mm) 34-1/16" ...
-
Alto-Shaam 1220 - page 15
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 13. 19-1/2" (495mm) 12-5/16" (312mm) 9-9/16" ( 242m m) 35-7/8" (910mm) 33-7/8" (860mm) 33" (837mm) 2" (50mm) 35-11/16" (905mm) 25" (635mm) 7-9/16" (191mm) 5" (126mm) Water Drain (Rear) Steam Vent (T op) 21-15/16" (557mm) ...
-
Alto-Shaam 1220 - page 16
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 14. 7•14 es TO P VIEW FRONT VIEW SIDE VIEW A rial MT Condensed Light 8 pt 43-3/4" (1111mm) 8-1/2" (216mm) 26-1/2" (672mm) 6-1/4" (159mm) 35-7/16" (899mm) 13" (330mm) 15-3/4" (400mm) 22-5/8" (576mm) 3-3/4" (95mm) 2-5/16" (58mm) W ...
-
Alto-Shaam 1220 - page 17
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 15. 7•14 es i TO P VIEW FRONT VIEW SIDE VIEW A rial MT Condensed Light 8 pt 43-3/4" (1111mm) 8-1/2" (216mm) 26-1/2" (672mm) 6-1/4" (159mm) 35-7/16" (899mm) 13" (330mm) 15-3/4" (400mm) 22-5/8" (576mm) 3-3/4" (95mm) 2-5/16" (58mm) ...
-
Alto-Shaam 1220 - page 18
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 16. 30" (760mm) 4-1 1/16" (120mm) 2-5/16" (58mm) 22-3/8" (568mm) 15-1/2" (393mm) 12-3/4" (323mm) Electrical Connection (Bottom) 2" (50mm) 46-7/8" (1 190mm) 43-7/8" ( 11 14mm) 41-15/16" (1064mm) 40-1/8" (1019mm) 25-5/8" ( ...
-
Alto-Shaam 1220 - page 19
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 17. 30" (760mm) 4-1 1/16" (120mm) 2-5/16" (58mm) 22-3/8" (568mm) 15-1/2" (393mm) 12-3/4" (323mm) Electrical Connection (Bottom) 2" (50mm) 46-7/8" (1 190mm) 43-7/8" ( 11 14mm) 41-15/16" (1064mm) 40-1/8" (1019mm) 25-5/8" ( ...
-
Alto-Shaam 1220 - page 20
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 18. 46-3/4" (1186mm) 44-3/4" (1136mm) 40-15/16" (1039mm) 1-13/16" (46mm) 48" (1218mm) 45-5/16" (1151mm) 33-1/2" (851mm) 2-1/16" (52mm) Water Drain (Bottom) 51-15/16" (1319mm) 2" (50mm) 76-15/16" (1954mm) 8-15/16" (226mm) ...
-
Alto-Shaam 1220 - page 21
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 19. 46-3/4" (1186mm) 44-3/4" (1136mm) 40-15/16" (1039mm) 1-13/16" (46mm) 48" (1218mm) 45-5/16" (1151mm) 33-1/2" (851mm) 2-1/16" (52mm) Water Drain (Bottom) 51-15/16" (1319mm) 2" (50mm) 76-15/16" (1954mm) 8-15/16" (226mm) ...
-
Alto-Shaam 1220 - page 22
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 20. 40-15/16" (1039mm) 1-13/16" (46mm) 46-3/4" (1186mm) 44-3/4" (1136mm) 4-3/4" (120mm) 2" (50mm) 51-15/16" (1319mm) Water Drain (Back) Steam Vents (T op) 76-15/16" (1954mm) 8-15/16" (226mm) 67-3/8" (1710mm) 76-1/4" (1936mm) ...
-
Alto-Shaam 1220 - page 23
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 21. 40-15/16" (1039mm) 1-13/16" (46mm) 46-3/4" (1186mm) 44-3/4" (1136mm) 4-3/4" (120mm) 2" (50mm) 51-15/16" (1319mm) Water Drain (Back) Steam Vents (T op) 76-15/16" (1954mm) 8-15/16" (226mm) 67-3/8" (1710mm) 76-1/4" (1936mm) ...
-
Alto-Shaam 1220 - page 24
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 22. ELECTRICAL CONNECTION INSTALLATION DANGER ENSURE POWER SOURCE MATCHES VOLTAGE STAMPED ON APPLIANCE NAMEPLATE. DANGER To avoid electrical shock, this appliance MUST be adequately grounded in accordance with local electrical codes or, in the absence of local codes, with the cur ...
-
Alto-Shaam 1220 - page 25
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 23. ELECTRICAL CONNECTION INSTALLATION DANGER ELECTRICAL CONNECTIONS MUST BE MADE BY A QUALIFIED SERVICE TECHNICIAN IN ACCORDANCE WITH APPLICABLE ELECTRICAL CODES. FINAL ASM, TOUCH SCREEN COMBICLEAN 5011685 Terminal Block Ground Electrical Connection DANGER To avoid electrical sh ...
-
Alto-Shaam 1220 - page 26
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 24. motor with rotation direction electrical connection electrical panel terminal block ground WARNING FOLLOWING ELECTRICAL CONNECTION, THE FAN MUST ROTATE IN THE SAME DIRECTION AS THE ARROW LOCATED ON THE OVEN FAN MOTOR. THIS APPLIANCE WILL NOT FUNCTION PROPERLY AND DAMAGE CAN O ...
-
Alto-Shaam 1220 - page 27
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 25. MOBILE EQUIPMENT RESTRAINT INSTALLATION Any appliance that is not furnished with a power supply cord but includes a set of casters must be installed with a tether. Adequate means must be provided to limit the movement of this appliance without depending on or transmitting str ...
-
Alto-Shaam 1220 - page 28
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 26. INSTALLATION WATER QUALITY REQUIREMENT WARNING TO PREVENT WATER PIPES OR HOSES FROM BURSTING, INCOMING WATER SUPPLY SHOULD BE TURNED OFF WHEN THE APPLIANCE IS NOT IN USE. WARNING WATER SUPPLY MUST BE OPEN WHEN CLEANING PROGRAM IS ACTIVATED. VERIFY WATER SUPPLY BEFORE STARTING ...
-
Alto-Shaam 1220 - page 29
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 27. INSTALLATION WATER CONNECTIONS WATER SUPPLY & INSTALLATION WATER REQUIREMENTS TWO (2) COLD WATER INLETS - DRINKING QUALITY ONE (1) TREATED WATER INLET: 3/4” NPT* ONE (1) UNTREATED WATER INLET: 3/4” NPT* LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar * Can manifold off of ...
-
Alto-Shaam 1220 - page 30
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 28. INSTALLATION WATER VALVE WATER DRAINAGE shut - off valve shown i n the off position NOTE: THE SHUT-OFF VALVE MUST BE IN THE OPEN POSITION WHEN THE OVEN IS BEING USED. The oven must discharge through an indirect waste pipe by means of an air gap. The drain fitting is supplied ...
-
Alto-Shaam 1220 - page 31
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 29. INSTALLATION CHECKLIST Use this list as a nal check of oven installation conformance. Damage directly attributed to improper set up, installation, or cleaning can invalidate warranty claims. CLEARANCES: Left: 6" (152mm) — Service access of 18" (457mm) recommend ...
-
Alto-Shaam 1220 - page 32
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 30. INSTALLATION There is a remote possibility in the day-to-day operation of the Combitherm that the control could lock or freeze. If this occurs, the control is easy to reset. PRESS AND HOLD THE POWER KEY FOR A PERIOD OF 5 SECONDS. Release the POWER KEY. The control will will r ...
-
Alto-Shaam 1220 - page 33
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 31. INSTALLATION ERROR CODES AND REASONS (continued) Error Code Display Shows When does the error occur? Possible reason E13 Excess Steam Gen Temp ES units only: Activatedifthetemperatureofthesteam generatorprobe(B-4)ishigherthan248°Ffo ...
-
Alto-Shaam 1220 - page 34
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 32. INSTALLATION cONTINUed ON NexT pAge ERROR CODES AND REASONS (continued) Error Code Display Shows When does the error occur? Possible reason E29 Probe Short to Frame Activatedifoneormoreofthetemperature sensors were connected to GND for 5 seconds. •? ...
-
Alto-Shaam 1220 - page 35
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 33. INSTALLATION In theevent of an error code, the Combithermmay be operated on a limited basis.Error conditions under which continued operation can be conducted are indicated by “Yes” in the chart shown below. When th ...
-
Alto-Shaam 1220 - page 36
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 34. INSTALLATION VENTLESS HOOD OPTION The Ventless Hood option is factory installed directly on the top of the Alto-Shaam Combitherm oven. The hood is designed to vent clean air back into the kitchen, filtering vapors and grease. A high-power fan draws steam and fumes into the ho ...
-
Alto-Shaam 1220 - page 37
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 35. INSTALLATION VENTLESS HOOD OPTION TOP LEVEL ASSY, VHES-5 HOOD FOR COMBI 5010692 TOP EXHAUST VENT 2 6 1 4 3 5 7 1 Ventless Hood Power Knob 2 Emergency Latch Release: This release is to be used ONLY if the timed latch mechanism is not working or in the event of a power outage. ...
-
Alto-Shaam 1220 - page 38
COMBITHERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 36. ORIGINAL EQUIPMENT LIMITED WARRANTY Alto-Shaam, Inc. warrants to the original purchaser that any original part that is found to be defective in material or workmanship will, at Alto-Shaam’s option, subject to provisions hereinafter stated, be replaced with a new or rebuilt ...
-
Alto-Shaam 1220 - page 39
TRANSPORTATION DAMAGE AND CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...
Do you have a question concerning Alto-Shaam 1220?
Use the form below
If you did not solve your problem by using a manual Alto-Shaam 1220, ask a question using the form below. If a user had a similar problem with Alto-Shaam 1220 it is likely that he will want to share the way to solve it.