English dropdown-ico

Manual Weil-McLain WGO

12 pages 0.51 mb
Download

Go to site of 12

Summary
  • Weil-McLain WGO - page 1

    WGO, WTGO and SGO-W WGO, WTGO and SGO-W WGO, WTGO and SGO-W WGO, WTGO and SGO-W WGO, WTGO and SGO-W Series 3 Series 3 Series 3 Series 3 Series 3 Oil-Fir Oil-Fir Oil-Fir Oil-Fir Oil-Fir ed W ed W ed W ed W ed W ater Boilers ater Boilers ater Boilers ater Boilers ater Boilers Part No. 550-141-828/1202 Part No. 550-141-828/1202 Part No. 550-141-828/12 ...

  • Weil-McLain WGO - page 2

    2 Hazard Definitions Following terms are used to bring attention to the presence of hazards of various risk levels, or to important information concerning product life. Indicates presence of hazards that will cause severe personal injury, death or substantial property damage if ignored. Indicates presence of hazards that can cause severe personal i ...

  • Weil-McLain WGO - page 3

    3 F or Y our Saf ety Follow instructions below to prevent severe personal injury, death or substan- tial property damage: Do not use crankcase drainings or any oil containing gasoline. See burner manual for proper fuel oil. Do not attempt to start burner when excess oil has accumulated in combustion chamber, when unit is full of vapor, or when comb ...

  • Weil-McLain WGO - page 4

    4 Routine Maintenance Schedule The schedule belo w is specifically designed for the homeo wner . Please read pa ges 2 and 3 bef ore pr oceeding. Beginning each heating season: Call a qualified service technician to perform annual service. Daily during heating season: Check that boiler area is free from combusti- ble materials, gasoline and other fl ...

  • Weil-McLain WGO - page 5

    5 Star t-up WGO/WTGO (see Figure 1): 1. If burner does not fire , check for: Service switch on boiler or additional switches turned off. Fuses or breaker switch tripped. Thermostat set below room temperature. Fuel valves turned off. Not enough oil in tank to supply burner. DANGE R WGO and WTGO Boiler s Figure 1 2. Correct problems found in step #1. ...

  • Weil-McLain WGO - page 6

    6 Star t-up SGO-W Boiler Figure 2 2. Correct problems found in step #1. If burner does not fire, press reset button on burner primary control only once. Repeated presses will deposit oil in combustion chamber. Burner must never be fired when oil is in combustion chamber. Immedi- ately call qualified service technician. 3. If burner still does not f ...

  • Weil-McLain WGO - page 7

    7 The problems and corrections above represent common situations that can occur. There may be others not listed above. It is important always to contact a qualified service techni- cian if you have any questions about the operation of your boiler or system. COMMON PROBLEMS COMMON CAUSES POSSIBLE CORRECTIONS Rapid cycling - burner turns on and off f ...

  • Weil-McLain WGO - page 8

    8 The pr ocedures and inf ormation on pag es 7 thr ough 11 ar e intended only f or a qualified ser vice technician who has the necessar y equipment to inspect and adjust boiler and burner . A homeo wner should ne ver attempt these pr ocedur es. Qualified ser vice technician must r ead pa ges 2 and 3 befor e proceeding. Annual Ser vice Check List An ...

  • Weil-McLain WGO - page 9

    9 Cleaning Boiler Flueways Figure 3 Thoroughly clean flueways between all pins at all angles. Start on top of boiler, finish from the bottom. Detailed Ser vice Pr ocedur es Cleaning boiler flueways: Make sure all electrical connections to boiler are turned off and wait until boiler is warm, not hot, before cleaning. Failure to do so will result in ...

  • Weil-McLain WGO - page 10

    10 Fill the system: 1. Close manual and automatic air vents and drain cock. 2. Fill to correct system pressure. Correct pres- sure will vary with each installation. Normal cold water fill pressure for residential systems is 12 psig. Boiler water pH 7.0 to 8.5 is recom- mended. Failure to maintain recom- mended pH level can cause section failure and ...

  • Weil-McLain WGO - page 11

    11 Detailed Ser vice Pr ocedur es Controls requiring annual service: WATER RELIEF VALVE: Check operation of water relief valve. Follow instructions on label fastened to relief valve. Scald potential. Do not check operation of relief valve unless discharge piping has been installed according to Boiler Manual. If piping is not in place, a qualified s ...

  • Weil-McLain WGO - page 12

    12 Part No. 550-141-828/1202 ...

Manufacturer Weil-McLain Category Boiler

Documents that we receive from a manufacturer of a Weil-McLain WGO can be divided into several groups. They are, among others:
- Weil-McLain technical drawings
- WGO manuals
- Weil-McLain product data sheets
- information booklets
- or energy labels Weil-McLain WGO
All of them are important, but the most important information from the point of view of use of the device are in the user manual Weil-McLain WGO.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Weil-McLain WGO, service manual, brief instructions and user manuals Weil-McLain WGO. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Weil-McLain WGO.

Similar manuals

A complete manual for the device Weil-McLain WGO, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Weil-McLain WGO by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Weil-McLain WGO.

A complete Weil-McLain manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Weil-McLain WGO - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Weil-McLain WGO, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Weil-McLain WGO, that we can find in the current document
3. Tips how to use the basic functions of the device Weil-McLain WGO - which should help us in our first steps of using Weil-McLain WGO
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Weil-McLain WGO
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Weil-McLain WGO in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Weil-McLain WGO?

Use the form below

If you did not solve your problem by using a manual Weil-McLain WGO, ask a question using the form below. If a user had a similar problem with Weil-McLain WGO it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)